Cub-cadet GT-3204 Uživatelský manuál

IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLYWarning: This unit is equipped with an internal combustion engine and should not be used on orn

10NOTE: References to LEFT andRIGHT indicate that side of the tractorwhen facing forward while seated inthe drivers seat. Reference to FRONTindicates

11Ignition / Light SwitchTo prevent accidental starting and/orbattery discharge, remove the keyfrom the ignition switch when thetractor is not in use.

12Seat Adjustment LeverThe seat adjustment lever is locatedbelow the seat. This lever is used toadjust the seat forward or backward. Deck Height Adjus

13Indicator Light PodFigure 12 ABCDEABCDEOil Pressure IndicatorLow Fuel IndicatorHour MeterNot UsedNot UsedHour MeterThe hour meter is part of the in

14SECTION 7: OPERATIONSafety Interlock SwitchesThis tractor is equipped with a safetyinterlock system for the protection ofthe operator. If the interl

15• Place the PTO switch in the “OFF”position. Place the throttle controllever between the “MID” and “FAST”positions. Then turn the ignition keyto the

16Avoid stopping when driving up aslope. If it is necessary to stop whiledriving up a slope, start up smoothlyand carefully to reduce the possibilityo

17Mowing should be done with theengine at full throttle. Do not mow athigh ground speed.During certain times of the year andunder some conditions, the

18Front Wheel AlignmentNote: The left-hand ball joint is left-hand threaded. The front wheels should toe-in approx-imately 1/8 inch. Measure distances

19From just above the right axle carrier,inside the right frame rail, slowly turnthe hex nylon lock nut at the end ofthe brake rod as follows to adjus

2TABLE OF CONTENTSPAGETRACTOR PREPARTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2IMPORTANT SAFE OPERATION PRACT

20LUBRICATION ILLUSTRATIONCub Cadet 251H EP Greaseor equivalent No. 2 lithium greaseEngine Oil: See Figure 27 on page 30Transmission Oil - Cub Cadet D

21Accessing Engine CompartmentThe engine compartment can beaccessed by raising the hood asfollows:• Lift the hood straight upward at therecessed notch

22with a solution of ammonia/water orbaking soda/water.• NEVER connect (or disconnect)battery charger clips to the batterywhile the charger is turned

23Charging the BatteryTest and, if necessary, recharge thebattery after the tractor has beenstored for a period of time.• A voltmeter or load tester s

24then fully reinserted before beingwithdrawn again for a true reading.Figure 21 Adding Transmission OilWARNING: The fluid for yourtransmission has b

25Figure 22 • Clean around the base of the trans-mission oil filter and remove thefilter by turning it counterclockwise.• Apply a light coating of cl

26FuseFuses are installed to protect the trac-tor’s electrical system from damagecaused by excessive amperage.Always use the same capacity fuse forrep

27SECTION 10: ENGINE INFORMATIONKOHLER CO.FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMSLIMITED WARRANTYSMALL OFF-ROAD EQUIPMENT ENGINESThe U.S. Envi

28LIMITATIONSThis Emission Control System Warranty shall not cover any of the following:(a) repair or replacement required because of misuse or neglec

29Cleaning The EngineThis tractor has an air-cooled engine.Air must be able to circulate freelyaround the engine through theflywheel screen, through t

31. GENERAL OPERATION• Read, understand, and follow allinstructions in the operator’s manualand on the machine before starting.Keep this manual in a

30Refer to Figure 27 for informationregarding the proper type of oil to addto the crankcase.• Place the tractor on a level surfaceand engage the parki

31• Attach the flexible tubing to thedrain valve. Place an appropriatecontainer below the open end of thetubing to collect the old oil.• To open the d

32WARNING: Operating theengine with loose or dam-aged air cleaner componentswill allow unfiltered air intothe carburetor, causing ex-tensive wear and

33SECTION 11: TROUBLE SHOOTINGPossible Cause Possible RemedyHard To StartNo fuel in fuel tank or carburetor Fill the tank with fuel. Check the fuel li

34Fuel tank air vent clogged Remove obstruction from the vent in the fuel tank cap.Air leakage between carburetor and engine Remove air cleaner. Tight

35SECTION 12: OPTIONAL EQUIPMENTWhen you purchased your tractor, you probably had it completely equipped foryour particular needs at that time. Howeve

36SECTION 13: SPECIFICATIONSEngineManufacturer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . KohlerHorsepower . .

37SECTION 14: SLOPE GAUGEWARNING: Do not mow on inclines with a slope in excess of 15degrees (a rise of approximately 2-1/2 feet every 10 feet). A ri

38

39CUB CADET LLCMANUFACTURER’S ONE YEAR LIMITED WARRANTY(COMMERCIAL USE)The limited warranty set forth below is given by CUB CADET LLC (“CUB CADET”)wit

4• Never leave a running machineunattended. Always turn off blade(s),place transmission in neutral, setpark brake, stop engine and removekey before di

40No implied warranty, including any implied warranty of merchantability orfitness for a particular purpose, applies after the applicable period ofexp

41CUB CADET LLCMANUFACTURER’S LIMITED WARRANTY(RESIDENTIAL USE)The limited warranty set forth below is given by CUB CADET LLC (“CUB CADET”)with respec

42b. CUB CADET does not extend any warranty for products sold or exportedoutside of the United States of America, its possessions and territories,exce

43

SECTION 15: QUICK REFERENCE PARTSDescription Part NumberEngine Oil 737-3030A (10W30)737-3049 (5W30)Air Filter KH-47-083-03KH-24-083-02Engine Oil Fil

5• Use extra care with grass catchersor other attachments. These canchange the stability of the machine.• Keep all movement on the slopesslow and grad

6• To reduce fire hazard, keep themachine free of grass, leaves orother debris build-up. Clean up oil orfuel spillage. Allow machine to coolat least 5

7SECTION 3: CALLING SERVICE INFORMATIONThe engine manufacturer is responsible for all engine-related issues withregards to performance, power-rating,

8SECTION 5: SAFETY LABELS FOUND ON YOUR UNITFigure 2 AVO ID SERIOUS INJURY OR DEATHREAD OPERATOR'S MANUALWARNINGGO UP AND DOWNSLOPES, NOT ACR

9ABCDEFGHIJKLMNOPQParking Brake LeverPTO SwitchBrake PedalReverse PedalForward PedalCenter Height Position IndicatorIgnition/Light SwitchTransmission